A number of times on the show it has been mentioned that an exhaust system without back pressure can lead to burned valves, notably the exhaust valve. I’ve talked to a few friends with auto experience and they agree this is the situation. However, this seems counterintuitive, and none of us can fu…

Good explanation, now I get it.

First, most racing engines are rebuild frequently. In the case of drag racing, after several runs (less than 10) the motors of highly sponsored teams get rebuilt. Therefore some valve burning is expected. The valves and heads are specifically designed and treated to tolerate conditions that would…

I don’t necessarily agree that lack of back pressure will burn exhaust valves. If that were the case many an airplane would have fallen out of the sky due to short exhaust stubs. In fact, one of the methods of IDing an aircraft at night during wartime was to note the exhaust flame patterns. Runnin…

It does make sense in the ‘no exhaust manifold or pipes’ case. But once any length of pipe is in place, I agree, then I don’t see it.

It has appeared to me that an open exhaust first and foremost causes a significant loss of low and mid range torque but when the engine is operated at wide open throttle under load and suddenly the throttle is closed, cold air is gulped back and will often warp a valve. Warping leaves a gap at the s…

The valve warping explanation makes more sense than the first lines of my last post re. oxygen. Otherwise the Overrun Fuel Cutoff would be a problem. When the engine is above idle speed and the throttle is closed no fuel is injected or burned, so more oxygen goes through into the exhaust. At any…

I used to hear this theory about the burned valves and took it as truth without ever thinking i through. Now I’m not so sure. I think a lot might depend on other factors. Cars with open pipes seem to burn valves, but cars with open pipes also have other modifications intended to force more fuel int…

Circuitsmith gave a pretty good answer. Changing exhaust back pressure can change the overall fuel mixture in carbureted engines…If you are talking about taking the muffler(s) off a modern fuel injected engine with a converter and two oxygen sensors ahead of the muffler, then it will not make any di…

I rode a number of motorcycles for many years with nothing more than drag pipes on them and never even saw a warped valve much less a burnt one. Adjusting the carburetor on a '65 and earlier Harley could be done while tooling down the road at highway speed. For many years belt and electrically ope…

Open exhaust & burned valves

General Discussion

FoDaddy June 14, 2011, 11:58pm 9

On street car you very rarely see burned valves anymore. I drove my Bronco for well over 150k miles with straight pipes, no cats, no mufflers, didn’t burn a valve or anything. My brother drove an F-150 with a similar exhaust for over 100k miles, and again no burned valves. It may have been more commonplace in the 50’s and 60’s but these days you just don’t see it.

Topic		Replies	Views
Massive oil burning under load but barely any at slow speeds - seems better with thicker weight oil Maintenance/Repairs	22	8944	October 25, 2012
Muffler size damages engines? Maintenance/Repairs chevrolet , suburban	37	29870	August 22, 2015
Is that a Blouse up your Muffler? The Show	42	4803	October 8, 2011
No Exhaust Maintenance/Repairs	5	1173	July 21, 2007
What causes PCV fails quickly? Maintenance/Repairs acura , integra	67	8743	March 8, 2021

Open exhaust & burned valves

Related topics