I have a 2004 Kia Rio that when the temperature outside is 70 or above,humidity 80 percent or over and misty or light rain, but rain that has continued for a long period of time that seems to soak whatever it is that is causing the issue, won’t start. It will try to crank, but if you continue to tr…

A common problem is that insulation on ignition wires (the ones that connect to the spark plugs) breaks down over time and absorbs moisture during rainy weather, causing the wires to short out, resulting in the car not starting. To check for this problem, wait until dark, then open the hood and spr…

+1 to @jesmed1 . This sounds like a wet distributor cap from the 70’s. New wires should solve your problem. Not related to your starting problems, you might want to change your spark plugs while you are at it if they have not been replaced yet.

This symptom is almost always due to a problem w/ the high voltage part of the ignition system. The thing is, electricity at high voltages isn’t easily confined to staying in the wires. The air we breath, it can actually conduct electricity too, at high voltages. And it is not just the air, elec…

I also use the troubleshooting procedure that jesmed1 uses. It works. I kept getting a “number 3 misfire” code from time to time…especially in damp weather. I started the engine in a very dark garage and discovered that the number 3 spark plug wire was bad. I replaced all of the spark plug wires and…

I know that all of the spark plugs and wires have been replaced in the last year. I also thought about the distributor cap, but the mechanic that looked at it said it was not that. I do believe the next thing is going to be going out and spraying with water at night and see what happens. Part of me …

How is the coil configured on this engine? Is it inside the distributor? Are there separate coils for each spark plug, located near the spark plug? The reason I ask is b/c one time I had a VW RAbbit that would stall every time I went over a puddle, and after many hours of diagnosis I discovered …

Even though your plug wires are less than a year old, one may have been resting too close to an exhaust manifold…which could damage the insulation. I would replace the cap as a diagnostic step. It will cost less than $10. The cap could have a very tiny hairline crack that could be the problem. So…

If it has a distributor, another thing to check when it does not start is to look and see if there is condensation inside the dist cap. This can occur if the rubber seal between the crankcase and the top portion of the distributor is not sealing; also if the rubber seal between the cap and the body …

2004 Kia Rio Won't Start During Rain

Maintenance/Repairs

rocketman October 4, 2015, 4:42pm 5

I would start by changing the spark plugs and wires. It’s probably just the wires, but why not change the plugs while you’re there? Throw in a new distributor cap, and post back please. Rocketman

Topic		Replies	Views
Car do not start Maintenance/Repairs	2	327	March 11, 2009
Starting Maintenance/Repairs kia , rio	3	559	December 4, 2009
Trouble starting '95 Civic in the rain Maintenance/Repairs	12	1129	June 19, 2012
Car starts somewhat roughly, idles horribly for a few seconds, then dies Maintenance/Repairs	2	1049	October 23, 2015
2004 Kia Rio Maintenance/Repairs	3	487	February 11, 2008

2004 Kia Rio Won't Start During Rain

Related topics