# 2002 Camry A/C intermitent damper problem **URL:** \ **Category:** Maintenance/Repairs\ **Created:** [May 15, 2008, 8:39pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069 "2008-05-15T20:39:58Z")\ **Posts on this page:** 11\ **Page:** 1
**Author:** ![mjwsatx](https://avatars.discourse-cdn.com/v4/letter/m/9e8a1a/32.png) [@mjwsatx](https://community.cartalk.com/u/mjwsatx)\ **Post date:** [May 15, 2008, 8:39pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/1 "2008-05-15T20:39:58Z")
I have a very intermitent problem with the a/c on my 2002 Camry. On long trips the a/c will gradually become less effective. I can hear the fan blowing like crazy, but very little air comes out of the vents no matter how I have the controls set - so I assume this is a damper problem. I mentioned this to the dealer who told me that I need to bring the car in when the problem occurs - but it only occurs when we travel at highway speeds for a couple of hours which we do rarely. We live in South Texas so it is a real PITA whenver it occurs. I was wondering if this was a common problem with Camrys or if anyone had any suggestions about what I could personally look for that would help me troubleshoot this problem. Thanks, Mike / San Antonio ---
**Author:** ![Tester](https://sea1.discourse-cdn.com/cartalk/user_avatar/community.cartalk.com/tester/32/15976_2.png) [@Tester](https://community.cartalk.com/u/Tester)\ **Post date:** [May 15, 2008, 9:37pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/2 "2008-05-15T21:37:25Z")
The problem might be with the thermal limit switch on the compressor. This is a protection device for the compressor in the event it begins to overheat. Or the compressor is actually overheating. Tester ---
**Author:** ![tardis](https://avatars.discourse-cdn.com/v4/letter/t/f0a364/32.png) [@tardis](https://community.cartalk.com/u/tardis)\ **Post date:** [May 15, 2008, 9:42pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/3 "2008-05-15T21:42:49Z")
Sounds more like the evaporator is freezing up. Could be low freon level. ---
**Author:** ![mjwsatx](https://avatars.discourse-cdn.com/v4/letter/m/9e8a1a/32.png) [@mjwsatx](https://community.cartalk.com/u/mjwsatx)\ **Post date:** [May 16, 2008, 1:52pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/4 "2008-05-16T13:52:25Z")
But the a/c normally works fine around town - even in the hottest weather. So it doesn’t seem likely that the freon level is low. As I said - when this problem occurs I can turn the fan on high but there is very little air that comes out of the vents, as if the vent dampers were closed. Mike ---
**Author:** ![tardis](https://avatars.discourse-cdn.com/v4/letter/t/f0a364/32.png) [@tardis](https://community.cartalk.com/u/tardis)\ **Post date:** [May 16, 2008, 3:25pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/5 "2008-05-16T15:25:58Z")
My limited experience with evaporator freeze up, required the car to run for over an hour continuously at highway speed for it to happen, and it did cool well until it froze. This was on a car that didn’t have the low pressure switch. I would think your car would have this, so it would have to be defective for freeze up to be the case. It could be something else, I don’t have any experience with Camry’s. A test for my theory. If I am correct, then once it happens, you should be able to stop (while air flow is low), turn the car off, and then quickly restart. Is the airflow still low? If so, it supports my theory (but doesn’t prove it). If not, then you do indeed need to look else where. You might also (when this happens) look for frost on the big AC line coming from the evaporator. So, when it does happen, how do you get the airflow to come back? ---
**Author:** ![tardis](https://avatars.discourse-cdn.com/v4/letter/t/f0a364/32.png) [@tardis](https://community.cartalk.com/u/tardis)\ **Post date:** [May 16, 2008, 6:13pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/6 "2008-05-16T18:13:53Z")
Hey, just found this. It is a TSB for freeze up for 2002-2003 Camry! Not low freon, but a design issue instead. AC001-03 Title: A/C PERFORMANCE & DURABILITY IMPROVEMENT Models: ?02 ? ?03 Camry Technical Service BULLETIN April 15, 2003 TSB UPDATE NOTICE: This TSB updates EL004?03. TSB EL004?03 is now obsolete and should be discarded. Some 2002 ? 2003 model year Camry owners may experience a condition where the blower volume gradually decreases after about 1-1/2 hours of driving. It has been determined that, in hot high humidity conditions, the A/C system evaporator is freezing over, blocking the airflow path. There may be some instances where this condition may affect the A/C compressor and clutch assembly. An in?line thermistor resistor harness is now available to correct this concern. ? 2002 ? 2003 model year Camry vehicles produced before the VINs shown below. PLANT STARTING VIN TMC JTDBE3#K#30187351 JTDBF3#K#30118354 TMMK 4T1BF3#K#3U040018 4T1BF3#K#3U547049 4T1BE3#K#3U146151 4T1BE3#K#3U668355 OP CODE DESCRIPTION TIME OFP T1 T2 AC2004 A/C Wire Installation 0.5 88501 07020 87 99 AC2005 Compressor With Magnetic Clutch 1.8 88501?95 99 Applicable Warranty\*: This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle?s in-service date. - Warranty application is limited to correction of a problem based upon a customer?s specific complaint. HEATING & AIR CONDITIONING Introduction Applicable Vehicles Production Change Information Warranty Information A/C PERFORMANCE & DURABILITY IMPROVEMENT ? AC001-03 April 15, 2003 Page 2 of 3 PREVIOUS PART NUMBER CURRENT PART NUMBER PART NAME ENGINE MODEL QTY 88648?33120\* 1 Air Conditioner Wire ? 1 88320?33160 TMC V6 88320?48080 Compressor Assembly TMC L4 1 88320?07090 TMMK V6 N/A 88320?06080 TMMK L4 88410?33120 TMC V6 88410?42040 Magnetic Clutch TMC L4 1 88410?33120 TMMK V6 88410?42040 TMMK L4 \*1 Air Conditioner Wire 88648?33120 includes a wire with register, a silencer sheet and a clamp band. 1. Compressor and Magnetic Clutch On?Vehicle Inspection. A. Start the engine. B. Inspect the compressor for a metallic rattle sound. a. Check if there is a metallic rattle sound from the compressor when the A/C switch is on. b. If a metallic rattle sound is heard, replace the compressor assembly. Please follow the instructions in the repair manual for compressor removal and replacement: ? V6 engine: page 55?50 ? L4 engine: page 55?57 C. Inspect magnetic clutch condition. a. Check the magnetic clutch for signs of overheating. b. If there are signs of overheating, replace the magnetic clutch. 2. Install Air Conditioner Wire. A. Remove instrument panel under cover sub?assembly No. 1, glove compartment door pad, instrument panel sub?assembly lower and heater to foot duct No. 1. B. Remove the cooler thermistor connector from the blower unit. NOTE: The cooler thermistor connector is clipped into the hole on the blower unit. Parts Information Repair Procedure A/C PERFORMANCE & DURABILITY IMPROVEMENT ? AC001-03 April 15, 2003 Page 3 of 3 C. Disconnect the connectors and install the air conditioner wire. D. Wrap the connector with the silencer sheet. E. Install the air conditioner wire clamp into the hole on the blower unit. F. Tie the connector onto the body wire harness with clamp band. G. Install the heater to foot duct No. 1, instrument panel sub?assembly lower, glove compartment door pad, and instrument panel under cover sub?assembly No. 1. Repair Procedure (Continued) Silencer Sheet ---
**Author:** ![crankwalk5](https://avatars.discourse-cdn.com/v4/letter/c/3e96dc/32.png) [@crankwalk5](https://community.cartalk.com/u/crankwalk5)\ **Post date:** [May 17, 2008, 1:37am UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/7 "2008-05-17T01:37:36Z")
please quit posting questions ,you already have the answer to.GROW UP! ---
**Author:** ![NYBo](https://sea1.discourse-cdn.com/cartalk/user_avatar/community.cartalk.com/nybo/32/17281_2.png) [@NYBo](https://community.cartalk.com/u/NYBo)\ **Post date:** [May 17, 2008, 1:55am UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/8 "2008-05-17T01:55:33Z")
Evaporator freezing was my first thought. Nice detective work, tardis. ---
**Author:** ![tardis](https://avatars.discourse-cdn.com/v4/letter/t/f0a364/32.png) [@tardis](https://community.cartalk.com/u/tardis)\ **Post date:** [May 17, 2008, 3:29am UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/9 "2008-05-17T03:29:31Z")
No, I only post answers to questions that I am fairly certain I know the answer to. (Unlike many here.) I haven’t posted any questions. At 42, I think I am quite grown up. For the record, the symptoms described are something that happened to me once, so I was pretty sure of the answer. After the reply doubting my diagnosis, I did a very simple Google search. It was for Camry evaporator freezing up. The TSB I posted was the fifth or sixth result. Frankly, I was lucky on this one. Most of my knowledge is of Mercury and Lincoln cars (of much of that applies to Ford too.) ---
**Author:** ![mjwsatx](https://avatars.discourse-cdn.com/v4/letter/m/9e8a1a/32.png) [@mjwsatx](https://community.cartalk.com/u/mjwsatx)\ **Post date:** [May 19, 2008, 7:23pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/10 "2008-05-19T19:23:53Z")
Thanks so much for researching this for me. I am sure that this must be the issue. I will print this out and drive it over to my dealer post haste and get this problem addressed before our scheduled trip to Houston (hot and humid) later this month. Mike ////////////// ---
**Author:** ![tardis](https://avatars.discourse-cdn.com/v4/letter/t/f0a364/32.png) [@tardis](https://community.cartalk.com/u/tardis)\ **Post date:** [May 19, 2008, 9:42pm UTC](https://community.cartalk.com/t/2002-camry-a-c-intermitent-damper-problem/14069/11 "2008-05-19T21:42:32Z")
If you’re out of warranty, a cheaper solution might be to put the air on recirculate on long trips.